Car steering Mitsubishi Carisma

Specifications and data
Specifications and data

General information about steering
Warning! Improper servicing or repair of any SRS component (or SRS-related component) may result in injury or death to the service personnel (due to unauthorized air bag...

Checking the steering wheel play
1. With the engine idling, position the front wheels parallel to the longitudinal axis of the vehicle (with the hydraulic power steering operating). 2. By turning the...

Checking the torque to start rotation of the ball joint of the steering rod end
1. Using a puller, disconnect the tie rod end from the steering knuckle. Caution! Use a special tool to loosen the ball joint pin nut. Do not completely remove the nut...

Checking the steering wheel turning force on a stationary vehicle
1. Place the vehicle on a level horizontal surface, with the front wheels parallel to the longitudinal axis of the vehicle. Attention! 2. Start the engine and set the...

Checking the steering wheel's independent return to the center position
This check requires a road test and the following. 1. While driving, make several smooth and then sharp turns of the steering wheel to the right and left in order to...

Replacing Power Steering Fluid
1. Jack up the front wheels of the car and place the car on stands. Fig. 13.5. Location of hoses when replacing fluid in the power steering: 1 – return hose; 2 – vinyl...

Bleeding the Power Steering Hydraulic System
1. Jack up the front wheels of the car and place the car on stands. 2. Manually turn the power steering pump pulley a few turns. 3. Make 5 or 6 full turns of the...

Checking the pressure generated by the power steering pump
Fig. 13.7. Connecting measuring instruments when checking the pressure of the hydraulic power steering pump: 1 – thermometer; 2 – adapter MV990993; 3 – pressure relief...

Checking the hydraulic fluid pressure switch sensor
Fig. 13.7. Connecting measuring instruments when checking the pressure of the hydraulic power steering pump: 1 – thermometer; 2 – adapter MV990993; 3 – pressure relief...

Steering wheel and steering shaft — removal and installation
Caution: On vehicles equipped with the Supplemental Restraint System (SRS), review the SRS safety precautions before removing the air bag module. Removal To remove the...

Steering shaft repair
Disassembly 1. Remove the steering shaft. Fig. 13.10. Locations for installing a hacksaw for metal (arrows) for cutting off special bolts for fastening the steering...

Steering gear with hydraulic power steering
Warning! For vehicles with the SRS, before removing the steering gear, set the front wheels parallel to the longitudinal axis of the vehicle and remove the ignition key....

Total torque for turning the steering gear pinion
1. Secure the steering gear in a vice. Caution! When installing the steering gear in a vice, clamp it only at the mounting points. If you clamp the steering gear in...

Checking the steering tie rod end turning resistance
To check the resistance of the steering tie rod end to turn, perform the following operations in sequence. 1. Turn the tie rod end ten times vigorously. Fig. 13.15....

Steering gear repair
Disassembly To disassemble the steering gear, perform the following operations sequentially. Fig. 13.16. Steering mechanism: a - places of lubrication application; 1 –...

Hydraulic power steering pump
Cars produced since 1996 Removal To remove the power steering pump, perform the following operations in sequence. 1. Drain the fluid from the power steering hydraulic...

Power Steering Hydraulic Hoses
Cars produced since 1996 Removal To remove the power steering hydraulic system hoses, perform the following operations in sequence. 1. Drain the fluid from the power...

Installing the return hose/low pressure hose
Fig. 13.26. Installing the power steering return/low pressure hose on vehicles manufactured since 1996: 1 – return hose; 2 – low pressure hose; 3 – mark pointing up Fig....

This section is available on: russian, bulgarian, belarusian, ukrainian, serbian, croatian, romanian, polish, slovak, hungarian

Similar materials for other Mitsubishi models

➤ Chassis and running gear: Steering Mitsubishi Colt 2 and 3 (1983-1993)
➤ Chassis and running gear: Steering Mitsubishi Lancer 9 (2000-2007, petrol)
➤ Chassis and running gear: Steering Mitsubishi Galant 6 and 7 (1987-1998)
➤ Chassis and running gear: Steering Mitsubishi L200 4 (2005-2014, diesel)
➤ Chassis and running gear: Steering Mitsubishi Outlander 1 (2003-2008)
➤ Chassis and running gear: Steering Mitsubishi Pajero 4 (2006-2021)

Share with friends:

Link in different formats to this section

TEXTHTMLBB Code