Car steering system Mitsubishi Pajero 4

General information
The cars are equipped with four-spoke steering wheels. The three-spoke steering wheel can be equipped with an airbag. The steering column is equipped with a shock...

Basic data for adjustments and control
Parameters Nominal value Maximum permissible value Steering wheel play, mm The engine is not working 10 or less With the power steering working 30 Angle of rotation...

Special tools
Drawing Name and code MB991897 or MB992011 Lateral tie rod ball joint puller MB9903326 Special tool MB991548 Adapter nipple (from the pump side) MB991549 Adapter nipple...

Checking the steering wheel play
1. With the engine running (the power steering works), install the front wheels strictly parallel to the longitudinal axis of the vehicle. 2. Measure the free play of...

Checking the steering angles of the steering wheels
1. Place the front wheels on the turning radius measuring stand and measure the turning angles of the steered wheels. Nominal value: Inner wheel: 36°49'±1°30' (short...

Checking the moment of the beginning of rotation of the ball joint of the steering rod end
1. Disconnect the steering rod end from the steering knuckle using a puller. Caution: Use a special tool to loosen the ball joint pin nut. Do not completely remove the...

Checking the amount of effort required to turn the steering wheel on a stationary vehicle
1. Place the vehicle on a level horizontal surface and set the steering wheel strictly parallel to the vehicle axis in the longitudinal direction. 2. Start the engine...

Checking the steering wheel's independent return to the center position
This check requires a road test and the following: 1. While driving, make several smooth and then sharp turns of the steering wheel to the right and left in order to...

Checking the fluid level in the power steering reservoir
1. Place the car on a level horizontal surface, start the engine and turn the steering wheel several times until the fluid temperature rises to approximately 50-60°C. 2....

Fluid replacement
1. Raise the front wheels of the car with a jack and place the car on sliding stands. 2. Disconnect the fluid return hose to the hydraulic system reservoir. 3. Place the...

Bleeding the Power Steering Hydraulic System
1. Raise the front wheels with a jack, and then place the car on sliding stands. 2. Manually turn the power steering pump pulley several times. 3. Turn the steering...

Checking the power steering pump pressure
1. Disconnect the high pressure hose from the pump and connect measuring instruments. 2. Release air from the hydraulic system and then, with the vehicle stationary,...

Checking the power steering hydraulic fluid pressure switch
1. Disconnect the high pressure hose from the pump and connect measuring instruments. 2. Remove air from the hydraulic system and then, with the vehicle stationary, turn...

Checking the ball joint protective covers
1. Check the protective cover for cracks and damage by pressing on it with your finger. 2. If the protective boot is cracked or damaged, replace the tie rod end. Note:...

Removal the steering wheel
Caution: On vehicles equipped with the Supplemental Restraint System (SRS), before removing the airbag module. 1. Remove the cover (1). 2. Remove the airbag module (2)....

Installing the steering wheel
1. Install the steering wheel (4). 2. Tighten the steering wheel fastening nut (3). 3. Install the airbag module (2). 4. Install the cover (1). 5. Check the position of...

Removal the steering shaft
Caution: On vehicles equipped with the Supplemental Restraint System (SRS), before removing the airbag module. 1. Remove the steering wheel and airbag module assembly....

Installing the steering shaft
1. Install the steering column mounting bracket (9). 2. Install the steering shaft (8). 3. Install the steering column shaft assembly (7). 4. Tighten the bolt (6). 5....

Disassembling the steering shaft
1. Unscrew the special bolt (1). 2. Remove the steering column lock bracket (2). 3. Remove the ignition switch (3). Note: If it is necessary to remove the ignition...

Removal the power steering gear
Caution: For vehicles with SRS, before removing the steering gear, set the front wheels parallel to the longitudinal axis of the vehicle and remove the ignition key from...

Steering shaft assembly
1. Install the steering shaft assembly (4). 2. Install the ignition switch (3). 3. Install the steering column lock bracket (2). 4. Tighten the special bolt (1)....

Installing a power steering gear
1. Install the power steering gear (13). 2. Install the clamp (12). 3. Install the sealing ring (11). 4. Connect the return pipe connection (10). 5. Connect the return...

Removal the power steering pump
Model with 3800 cc engine 1. Remove the battery and battery tray. 2. Drain the fluid from the power steering hydraulic system. 3. Remove the drive belt (1). 4. Remove...

Installing a Power Steering Pump
Model with 3800 cc engine 1. Install the power steering pump bracket (7). 2. Install the intermediate pulley of the timing belt of the gas distribution mechanism and the...

Checking the power steering pump
1. Check that the fluid flow control valve is not clogged. 2. Check the pulley assembly for wear or damage. 3. Check for the absence of "stepped" wear on the blades and...

Removal the power steering hydraulic hoses
1. Drain the fluid from the power steering hydraulic system. 2. Remove the power steering expansion tank bracket (1). 3. Remove the power steering expansion tank (2). 4....

Installing Power Steering Hydraulic Hoses
1. Install the sealing ring (17). 2. Install the return pipe (16). 3. Install the return hose (15). 4. Install the return pipe (14). 5. Install the return hose (13). 6....

This section is available on: russian, bulgarian, belarusian, ukrainian, serbian, croatian, romanian, polish, slovak, hungarian

Similar materials for other Mitsubishi models

➤ Chassis and running gear: Steering Mitsubishi Colt 5 (1995-2003, petrol)
➤ Chassis and running gear: Steering Mitsubishi Lancer 9 (2000-2007, petrol)
➤ Chassis and running gear: Steering Mitsubishi Galant 6 and 7 (1987-1998)
➤ Chassis and running gear: Steering Mitsubishi L200 4 (2005-2014, diesel)
➤ Chassis and running gear: Steering Mitsubishi Outlander 1 (2003-2008)
➤ Chassis and running gear: Steering Mitsubishi Carisma (1995-2004)

Share with friends:

Link in different formats to this section

TEXTHTMLBB Code

Pajero 4 (2006-2021)

Pajero 1 and 2 (1982-1999)